Audi 100

1982-1990 of release

Repair and car operation




Audi 100
+ 1.1. Governing bodies and devices
+ 2. Technical characteristics
+ 3. Engines
+ 4. Cooling system
+ 5. Exhaust system
+ 6. Power supply system
+ 7. Transmission
+ 8. Running gear
+ 9. Steering
+ 10. Brake system
+ 11. Body
- 12. Electric equipment
   - 12.1. Electric equipment system
      12.1.1. Technical characteristics
      12.1.2. Safety locks, relay and control units
      + 12.1.3. Generator
      + 12.1.4. Starter
      - 12.1.5. Lighting and light alarm system
         12.1.5.1. Replacement of a lamp of a headlight
         12.1.5.2. Replacement of a lamp of dimensional light
         12.1.5.3. Removal and headlight installation
         12.1.5.4. Adjustment of light of headlights
         12.1.5.5. Replacement of a lamp of the index of turn
         12.1.5.6. Removal and installation of the index of turn
         12.1.5.7. Replacement of a lamp of a fog light
         12.1.5.8. Adjustment of light of fog lights
         12.1.5.9. Replacement of lamps of a back lamp on a wing
         12.1.5.10. Replacement of lamps of a back lamp on a trunk lid
         12.1.5.11. Replacement of a lamp of a lamp of illumination of registration plate
         12.1.5.12. Replacement of a lamp of a lamp of illumination of a luggage carrier
         12.1.5.13. Replacement of a lamp of a plafond of illumination of salon
         12.1.5.14. Replacement of a lamp of a plafond of a directional light
         12.1.5.15. Removal and installation of a combination of devices
         12.1.5.16. Voltage stabilizer check
         12.1.5.17. Removal and installation of the relay breaker of indexes of turn
         12.1.5.18. Check of the switch of light of a backing
         12.1.5.19. Check of the sensor of the index of temperature of cooling liquid
         12.1.5.20. Verification of the index of level of fuel
         12.1.5.21. Adjustment of the index of level of fuel
         12.1.5.22. Removal and installation of a screen wiper of a windscreen
   + 12.2. Ignition system
   + 12.3. Electric circuits


работа в Москве



12.1.5. Lighting and light alarm system

12.1.5.1. Replacement of a lamp of a headlight

GENERAL INFORMATION

Car headlights

1–headlight;

2–turn index;

3–fog light;

4–decorative frame of a fog light

Headlight and turn index

1–boss of a lamp of the index of turn;
2–lamp of the index of turn;
3–turn index;
4–headlight;
5–the screw of adjustment of a headlight in the vertical plane;
6–headlight rack;
7–screw;
8–screw of fastening of a headlight;
9–the screw of adjustment of a headlight in the horizontal plane;
10-the boss with a headlight lamp;
11-connecting block

View of a headlight from an engine compartment: а) – the protective cap is removed; б) – the protective cap is established

1–connecting block;

2–the screw of adjustment of light of headlights in the horizontal plane;

3–boss of a lamp;

4–spring holder of the boss;

5–the screw of adjustment of light of headlights in vertical situation;

6–protective cap


Replacement

PERFORMANCE ORDER
1. To open a cowl and to disconnect a wire from the "minus" plug of the storage battery.
2. To turn and remove a protective cap of the case of a headlight.
3. To disconnect a block with wires from the boss of a lamp.
4. To wring out the spring holder of the boss.
5. To take out a cartridge and to replace a lamp, thus not to undertake a lamp flask hands. It is possible to undertake a galogenovy lamp only in pure gloves or by means of a pure fabric.
6. To insert a cartridge and to fix it the holder.
7. To connect a block with wires to the boss of a lamp.
8. To establish a protective cap of the case of a headlight. Thus «Oben» label on a cap should be from above.